菠萝彩票开户

    高空作業平臺車安全操作時注意那些

    作者:湖北江南汽車  發布時間:2018-02-28 新聞瀏覽熱度:

(1)XIACHECAOZUOSHIDEZHUYISHIXIANG。XIACHECAOZUOYIBANWEIZHITUICAOZUO。YINGANZHAOZHISHIPAIJINXINGCAOZUO。CAOZUOSHIYINGZHUYI: a.ZAIGAODIBUPINGCHANGDIHUOZHITUIZHICHENGCHUDIJIJIAORUANSHI,YAOYONGDAMUKUAIDIANZAIZHITUIZHIJIAOPANXIA; b.BANDONGZHITUIKAIGUAN,SHIZHUANGZAIZHITUISHANGDEJINGSHIDENGLIANG,TIXINGGUOWANGCHELIANGYUXINGRENZHUYIGUANCHA; c.YANGECAOZUOSHUNXU:JIANSHUNXUXIANSHENCHUSHUIPINGZHITUI,ZAISHUIPINGZHITUIQUANBUSHENCHUHOUZAISHENCHUIZHIZHITUI,DANGSUOYOUZHITUIQUANBUSHENCHUHOUFANGKECAOZUOSHANGCHE; d.YINZHITUISHENCHUGUOCHENGZHONG,CHELIANGZHANJUDECHANGDIBUDUANZENGDA,ZAIZHITUISHENCHUGUOCHENGZHONGYINGZHUYIGUANCHAGUOWANGCHELIANGHEXINGREN,SUISHITINGZHICAOZUO,SHENZHISHOUHUIZHITUI; e.ZHUYIGUANCHASHUIPINGYI,YIBAOCHIZHENGCHESHUIPING,YINGSHISHUIPINGYIDEQIPAOWEIYUZUIXIAODEYUANQUANNEI,FOUZE,YINGZAIDIAOJIEZHITUI, SHIZHENGCHESHUIPING; f.GUANCHAZHITUIDAOWEIZHISHIDENG,BINGQUERENZHITUISHENCHUDAOWEI; g.ZHITUICAOZUOWANBIHOU,YINGBODONGDIANYUANKAIGUANQIEDUANXIACHEDIANYUAN; h.ZHITUISHENCHUHOU,LUNTAIBIXULIKAIDIMIANYIDINGJULI(30~80mm); i.ZHITUICAOZUOWANBIHOU,QIEJIJIANGCAOZUOSHOUBINGHUIFUZHIZHONGWEI,YIMIANZAISHANGCHECAOZUOSHIWUCAOZUOXIACHEZAOCHENGWEIXIAN。

(2)上車操作時的注意事項。高空作業車臂架舉升和回轉操作稱為上車操作。操作時應注意: a.首先按動喇叭,鳴叫示意和提醒相關人員注意,防止意外墜落的物品砸傷行人。注意喇叭持續鳴響的時間不少于2s、不得大于1min; b.操作過程中,應注意垂直支腿狀態指示燈有無全部點亮,如發生軟腿現象,應立即停止上車操作。c.注意觀察各機構是否達到極限位置,隨時停止操作; d.作業車工作時,與懸崖和溝渠邊緣應保持足夠的安全距離; e.當在工作范圍有電線通過時,應始終保持足夠的安全距離; f.如果是帶電作業,應確保有效絕緣長度足夠后方可作業; g.帶起重功能的高空作業車,在操作臂架時,還應注意觀察起重繩長度變化,防止拉斷起重鋼絲繩; h.操作時不可突然啟動或加速,應保證操作平穩; i.只有當臂架完全脫離臂支架后,才能進行回轉; j.作業車液壓油溫超過70℃時,應停機休息,降溫后再使用; k.工作完畢,應使工作臂及工作平臺回到初始位置,尤其注意下臂落下后,應與臂支架配合好,不得懸空; l.對伸縮臂高空作業車,操作臂架伸出時,應注意觀察幅度或力矩限制器的工作狀態,防止幅度或力矩限制器出現故障而發生危險。
(3)取力操縱時的注意事項。在操作取力之前,應首先再次確認手剎車應處于剎車狀態。然后將變速桿置于空檔位置,踩下離合器踏板, 扳動取力器開關,使取力箱內取力齒與變速箱內的齒輪嚙合,然后慢慢松開離合器踏板,使油泵運轉。油泵運轉后,檢查轉動時有無異常聲響, 確定運轉正常后,方可進行下一步操作。

(4)GAOKONGZUOYEHOUDEANQUANSHIXIANG。WANCHENGGAOKONGZUOYEHOU,YINGANZHAOXIANGYINGDESHUNXUJIANGGEGONGZUOJIGOUSHOUHUIZHIXINGSHIZHUANGTAI:XIANSHUNXUSHOUHUIBEIJIABINGJIANGBEIJIAZHIYUBEIZHIJIASHANG,ZAISHOUHUIZHITUI,ZAIZHAICHUQULI,BINGJIANGSUOYOUSUICHEGONGJIQIJU、YUANFUCAILIAO、ZHITUIDIANBANDENGFUJIANSHOUHUIBINGFANGZHIDAOGUIDINGZHUANGTAI。SHOUHUICAOZUOSHIYINGCANZHAOSHENCHUCAOZUOSHIDEZHUYISHIXIANGNIXIANGCAOZUO,LINGWAIHUANYOUYIXIEZHUYIDIAN: a.SHANGCHEGEBUFENMEIYOUSHOUHUIDAOXINGSHIZHUANGTAI,JINZHICAOZUOXIACHEZHITUI; b.ZHIYOUDANGBEIJIADADAOJIEJINDUIZHUNBEIZHIJIAHOU,CAINENGJIANGBEIJIALUOZHIBEIZHIJIASHANG,FOUZEYINGJINXINGZUOYOUHUIZHUANDUIZHONG;ZHUYIXIABEILUOXIAHOU,YINGYUBEIZHIJIAPEIHEHAO,BUDEXUANKONG。

湖北江南專用特種汽車有限公司官網 4x5r.com